Product Name:
|
Cerama-Tech
1646 Via Del Mesonero
San
Diego, CA 92173 | |
|
Product Information
| Chemical Name: Vinyl
Acrylic |
 |
| Formula No.: 100 |
| Chemical Family: Vinyl Acrylic |
| Trade Name: Cerama-Tech |
| Hazard Rating: Fire - 1, Toxicity - 0,
Reactivity - 0 | |
|
I - Physical Data |
| Appearance, Odor: liquid, mild odor |
Solubility in water: Yes |
| Boiling Point: 250 degrees |
Specific Gravity(H2O=1): 1.428 |
| Vapor Pressure(mm Hg): 0.2 |
Percent Volatile by Volume: 42.22% |
| Vapor Density (air=1): N/A |
Evaporation Rate (Butyl Acetate = 1):
N/A | |
|
II - Hazardous Ingredients
|
|
Material - Case No. |
OSHA PEL |
TLV |
|
Ethylene Glycol - 107-21-14 |
N/A |
100 PPM |
|
Texanol - 25265-77-4 |
N/A |
N/A | |
|
III - Fire and Explosion Hazard Data
|
| Flash Point: 248 degrees |
LEL%: .62 |
UEL(%): 4.24 |
| Auto Ignition Temperature: that of
water |
|
| DOT Category: NON FLAMMABLE |
|
| Special Firefighting Procedures: |
Avoid confined spaces unless properly protected
against potential irritating and toxic fumes. |
| Unusual Fire and Explosion Hazards: |
KEEP AWAY FROM HEAT. Containers may explode when
exposed to extreme
heat. | | |
|
IV - Reactivity Data
|
| Stability: Stable |
Conditions to Avoid: N/A |
| Incompatibility(materials to avoid) |
Strong Oxidizers |
| Hazardous Decomposition Products |
Carbon Dioxide |
| Hazardous Polymerization |
Will not Occur |
| Condition to Avoid |
Contact with strong oxidizers | |
|
V - Health Hazard Data |
| Threshold Limit |
100PPM |
| Effects of Over Exposure |
Inhalation of high vapor concentrations may have results
ranging from dizziness and headaches to unconsciousness |
| Emergency First Aid Procedures |
If ingested, drink water to dilute, DO NOT induce
vomiting. Remove to fresh air, wash skin with soap and water.
Flush exposed eyes with water for 15 minutes or until
irritation subsides. | |
|
VI - Spill or Leak Procedures
|
| Steps to be taken in case material is released or
spilled |
Clean spills immediately with absorbent such as clay or
sand. |
| Waste Disposal Method |
Dispose of in accordance with Local, State, and Federal
regulations | |
|
VII - Spill or Leak Procedures
|
| Respiratory Protection |
Avoid excessive vapor inhalation. Use and
approved NIOSH respirator. |
| Ventilation |
Mechanical ventilation may be used if needed
to control mist or vapor. |
| Protect Gloves |
Neoprene Gloves |
| Eye Protection |
Safety glasses or face
shield | |
|
VIII - Special Precautions
|
| Storage and Handling |
Keep away from heat or flame |
| Other Precautions |
Avoid unnecessary
exposure | |
